Numerical Study of a Turbulent Single-Stage Axial Flow
DOI:
https://doi.org/10.15377/2409-5761.2016.03.01.2Keywords:
Axial flow, turbomachinary, angular velocity, turbulence model, CFDAbstract
This paper studies the flow in an axial fan with a rotor in front and stators (vanes) in the rear. This configuration is typical of a single-stage axial flow turbo machine. The standard  model with enhanced wall treatment. Interaction between these components is determined considering the rotor and stator together in a single calculation. Numerical calculations have been performed to investigate the effects of different angular velocities on pressure contours, mass flow rates and total pressure and the results have been shown and discussed through figures. The results show that the increase of angular velocity has a significant effect on the governing physical parameters.
Downloads
References
Chamorro LP, Hill C, Morton S, Ellis C, Arndt REA and Sotiropoulos F. On the interaction between a turbulent open channel flow and an axial-flow turbine. J Fluid Mech 2013; 716: 658-670. http://dx.doi.org/10.1017/jfm.2012.571 DOI: https://doi.org/10.1017/jfm.2012.571
Foad Vashahi, Sangho Lee and Jeekeun Lee. Experimental Analysis Of The Swirling Flow In A Model Rectangular Gas Turbine Combustor. Experimental Thermal and Fluid Science 2016; 76: 287-295. http://dx.doi.org/10.1016/j.expthermflusci.2016.03.032 DOI: https://doi.org/10.1016/j.expthermflusci.2016.03.032
Mehdi Azimian and Hans-Jörg Bart. Computational analysis of erosion in a radial inflow steam turbine. Engineering Failure Analysis 2016; 64: 26-43. http://dx.doi.org/10.1016/j.engfailanal.2016.03.004 DOI: https://doi.org/10.1016/j.engfailanal.2016.03.004
Zhengping Zou, Jingyuan Liu, Weihao Zhang and Peng Wang. Shroud leakage flow models and a multi-dimensional coupling CFD (computational fluid dynamics) method for shrouded turbines. Energy 2016; 103: 410-429. http://dx.doi.org/10.1016/j.energy.2016.02.070 DOI: https://doi.org/10.1016/j.energy.2016.02.070
Anker JE and Mayer JF. Simulation of the interaction of labyrinth seal leakage flow and main flow in an axial turbine 2002. ASME paper no. GT2002e30348. DOI: https://doi.org/10.1115/GT2002-30348
Wallis AM, Denton JD and Demargne AAJ. The control of shroud leakage flows to reduce aerodynamic losses in a low aspect ratio, shrouded axial flow turbine. J Turbomach 2001; 123: 334e41. DOI: https://doi.org/10.1115/1.1354143
Rosic B, Denton JD and Pullan G. The importance of shroud leakage modeling in multistage turbine flow calculations. J Turbomach 2006; 128: 699e707. DOI: https://doi.org/10.1115/1.2181999
Rosic B and Denton JD. Control of shroud leakage loss by reducing circumferential mixing. J Turbomach 2008; 130: 021010(1-7). DOI: https://doi.org/10.1115/1.2750682
Rosic B, Denton JD, Curtis EM and Peterson AT. The influence of shroud and cavity geometry on turbine performance: an experimental and computational studypart2: exit cavity geometry. J Turbomach 2008; 130: 041002(1-10). DOI: https://doi.org/10.1115/1.2777202
Giboni A, Wolter K, Menter JR and Pfost H. Experimental and numerical investigation into the unsteady interaction of labyrinth seal leakage flow and main flow in a 1.5-stage axial turbine. 2004. ASME paper no. GT2004e53024. DOI: https://doi.org/10.1115/GT2004-53024
Pfau A. Loss mechanisms in labyrinth seals of shrouded axial turbines
E Ghasemi, DM McEligot, KP Nolan, J Crepeau, A Tokuhiro and RS Budwig. Entropy generation in a transitional boundary layer region under the influence of freestream turbulence using transitional RANS models and DNS, International Communications in heat and Mass transfer 2013; 41: 10-16. http://dx.doi.org/10.1016/j.icheatmasstransfer.2012.11.005 DOI: https://doi.org/10.1016/j.icheatmasstransfer.2012.11.005
Downloads
Published
Issue
Section
License
All the published articles are licensed under the terms of the Creative Commons Attribution Non-Commercial License (CC BY-NC 4.0) which permits unrestricted, non-commercial use, distribution and reproduction in any medium, provided the work is properly cited.
